![]() If you see any leaks or bubbles, replace the fuel line tubing. Turn off the machine and inspect the lines. You can remove debris by running the machine at idle for a few minutes with low-pressure fuel from a long hose. This problem can occur when debris causes the air to stop flowing into the tank. To fix the issue, spray the electrical contact cleaner on the solenoid terminals and reinstall it. This issue can occur if the electrical wiring is damaged or corroded. This faulty part has been known to cause the engine to stop working or even turn off while on the road or in use. John Deere fuel shut off solenoid problem is a relatively common, but serious problem that can occur on all John Deere diesel engines. John Deere Fuel Shut off Solenoid Problems with Fix Thankfully, John Deere offers a factory warranty on their products, so if your fuel shut off solenoid does fail within the first year or two of ownership, you should be able to get a replacement free of charge. If this is the case, it will need to be replaced. If you suspect this is the problem, you’ll need to check and tighten all of the connections between these two parts.įinally, there’s also a chance that the fuel shut off solenoid itself may be faulty. ![]() This can cause intermittent starting problems or even prevent the engine from starting altogether. If this happens, you’ll need to clean or replace the fuel shut off solenoid.Īnother problem that can occur is that the electrical connection between the fuel shut off solenoid and the engine control unit can become loose or damaged. This can be caused by dirt or debris build-up, and it can prevent the engine from starting. ![]() One of the most common problems is that the fuel shut off solenoid can become stuck in the “on” position. Please read below to know more about John Deere Fuel Shut off Solenoid Problems. How should I go about diagnosing if there are other problems? If it were just a bad solenoid I suspect the first symptom would not have been it dying and then starting again but dying when put in gear.If you have a John Deere tractor and it’s having John Deere Fuel Shut off Solenoid Problems, there are a few things you can do to try and fix the issue. Is this a symptom of a bigger issue?Ĭould it be related to running it with the bad battery?Īt $180 a pop for a new solenoid I don't want to just replace and fry the new one if there is an underlying problem. Obviously I need a new solenoid but I'm wondering what might have caused this. I touched it and blistered my finger it was so hot. I shut off and stepped back, looking for flames and when I didn't see any and the smoke cleared I popped the hood and took off the side panel and could see the end of the fuel shutoff solenoid was melted. I restarted and then heard a hissing noise and smoke poured out from under the tractor and it smelled of electrical stuff burning. I started again, got off, lifted the seat and manually pushed the safety switch under the seat and then put it in gear and it immediately died. I put it in neutral and jump started it again but when I put it in gear it died, even though I was on the seat. ![]() I jumped it and was running it for about 30 minutes or so that then it died on me like the key was turned off. I have a problem with my 4100 hydro and was hoping someone on here might be able to help.įor reasons I wont get into I was running with a dead battery that would not take a charge.
0 Comments
Leave a Reply. |
AuthorWrite something about yourself. No need to be fancy, just an overview. ArchivesCategories |